Powertrain Malfunction/ Reduced Power

[LightningShow]

My battery has now been out 3 times. Its a 2022. As much as I want to love this truck, its held together with hopes and prayers... and that just doesnt really cut it.

I'm holding out for a full battery replacement when they get the issues fully sorted out. Sounds like they aren't there yet since 2024s are still having issues. I'm willing to take the risk of holding until they do, or don't, decide on a full battery recall. Clearly, the failure rate on these modules is excessive so it probably behooves them to recall the the entire pack rather than picking away one module replacement at a time for each truck for 7 years or 100k miles.

Sponsored

 

[Zprime29]

I got my truck back today, 9 days after I brought it in. They actually called me a couple of days ago and said they were working on installing the new array but the tech didn't like something about one of the parts so they ordered another, hence another couple days delay. I had 10k mile service and they did updates for the front hatch control module and front parking sensors. I had to gas up the loaner they gave me before I returned it and had to roll my eyes at the $95 it cost me... but as I mentioned before, I am going to try and get this reimbursed by Ford, the service manager gave me a number to call for that.

First thing I did was go to a DCFC and make sure that worked which it did. Then I plugged it in when I got home and sure enough, works as it did before. All in all, it wasn't a very painful experience since they provided a loaner. Maybe I just have a better Dealer here?

Keep an eye on the coolant, couple reports of it going low as things settle. Also, there's a post somewhere that explains it'll take a few weeks for the BMS to fully settle in after a module replacement. Don't fret if you see your range est get a little wonky (at least more than usual).

 

[LightningShow]

I got my truck back today, 9 days after I brought it in.

Nice turnaround. As of yesterday, the dealer is saying I'll get it back today. Monday would be 4 weeks since I brought it in.

 

[Whammy Bar]

Keep an eye on the coolant, couple reports of it going low as things settle. Also, there's a post somewhere that explains it'll take a few weeks for the BMS to fully settle in after a module replacement. Don't fret if you see your range est get a little wonky (at least more than usual).

Second this on the coolant level. They never bleed the systems correctly (assuming they put it back together correctly). Mines down over an inch since having it back for a week for the same thing.

 

[LightningShow]

I got the call to come pick up my truck. Finally.

 

[dancwilliams]

Wanted to provide an update. Took my truck in on the morning of 11/11 and got it back that evening. They did some updates and reset some things. Light came back on during the ride home. It had gone off the following midday but came back on yesterday afternoon and I happened to be right by the dealership so I dropped it off again. We shall see. Ford Corporate did contact me via phone concerning my case so that was nice. Hope they can figure it out!

 

[AmandaB]

I got the Service Vehicle Soon warning on Thursday. ‘22 Lariat ER with 45k miles. Reduced power at 57% drives fine but won’t charge. Had someone run the VIN and it’s saying the below. I have an appointment next week.

POB24:21 Hybrid/EV Battery 'A' Voltage Unstable: Signal Amplitude Less Than Minimum

 

[The Weatherman]

I got the Service Vehicle Soon warning on Thursday. ‘22 Lariat ER with 45k miles. Reduced power at 57% drives fine but won’t charge. Had someone run the VIN and it’s saying the below. I have an appointment next week.

POB24:21 Hybrid/EV Battery 'A' Voltage Unstable: Signal Amplitude Less Than Minimum

It’s looking more and more likely that a bunch of us 2022 early adopters are gonna face this issue eventually.

It is extremely uncomfortable having this hanging over my head and not knowing when it’s going to strike.

Come on @Ford Motor Company let’s get proactive here.

 

[AmandaB]

It’s looking more and more likely that a bunch of us 2022 early adopters are gonna face this issue eventually.

It is extremely informally having this hanging over my head and not knowing when it’s going to strike.

Come on @Ford Motor Company let’s get proactive here.

I agree it does appear that way.

Sponsored